Can-Am ATV & UTV Forums banner
1 - 4 of 4 Posts

· Registered
Joined
·
1 Posts
Discussion Starter · #1 ·
Just throwing this out there to see if anyone else has experienced this chirping like sound coming from what I thought was the clutch/belt on my 2022 Can-am outlander XTP max, if I could accurately describe it I would say it sounds just like a rickety old golf cart when you take off from a stand still, it’s been to the local dealer a few times to where they polished up the clutch, changed the one way bearing and put a new belt on, went back again and they found the clutch sliders were too tight or something like that. I’ve also found by accident that the sound did go away once when I stood up off the seat, not sure if that was a coincidence though or not, my other ATV’S didn’t do it including my 2021 xt 850, the dealer hasn’t given up on it but they have literally gone over everything, your input is greatly appreciated guys, thanks!

The machine has 680 kms on it
 

· Registered
Joined
·
4,563 Posts
I have had a chirping noise before that ended up being a rear diff, i replaced the fluid with 75-140 synthetic and that took care of the problem, you may also want to change out the trans fluid as well with 75-140. hard to diagnose a chirp as it sounds like it could be coming from several locations. i would also make sure all your drive shaft bolts are tight and not coming loose as that is a common problem. if the clutch fingers are sticking i would remove them and sand them. lots of things can cause a chirp.
 
1 - 4 of 4 Posts
Top